Mucosal Immunization with a Novel Nanoemulsion-Based Recombinant Anthrax Protective Antigen Vaccine Protects against Bacillus anthracis Spore Challenge
ABSTRACT
The currently available commercial human anthrax vaccine requires multiple injections for efficacy and has side effects due to its alum adjuvant. These factors limit its utility when immunizing exposed populations in emergent situations. We evaluated a novel mucosal adjuvant that consists of a nontoxic, water-in-oil nanoemulsion (NE). This material does not contain a proinflammatory component but penetrates mucosal surfaces to load antigens into dendritic cells. Mice and guinea pigs were intranasally immunized with recombinant Bacillus anthracis protective antigen (rPA) mixed in NE as an adjuvant. rPA-NE immunization was effective in inducing both serum anti-PA immunoglobulin G (IgG) and bronchial anti-PA IgA and IgG antibodies after either one or two mucosal administrations. Serum anti-PA IgG2a and IgG2b antibodies and PA-specific cytokine induction after immunization indicate a Th1-polarized immune response. rPA-NE immunization also produced high titers of lethal-toxin-neutralizing serum antibodies in both mice and guinea pigs. Guinea pigs nasally immunized with rPA-NE vaccine were protected against an intradermal challenge with ∼1,000 times the 50% lethal dose (∼1,000× LD50) of B. anthracis Ames strain spores (1.38 × 103 spores), which killed control animals within 96 h. Nasal immunization also resulted in 70% and 40% survival rates against intranasal challenge with 10× LD50 and 100× LD50 (1.2 × 106 and 1.2 × 107) Ames strain spores. Our results indicate that NE can effectively adjuvant rPA for intranasal immunization. This potentially could lead to a needle-free anthrax vaccine requiring fewer doses and having fewer side effects than the currently available human vaccine.
Until recently, new vaccines for inhalational anthrax were not aggressively pursued because anthrax was regarded as a rare infection with an effective vaccine. The currently licensed United Kingdom and U.S. human anthrax vaccines were developed over 30 years ago and consist of supernatants from toxigenic strains of Bacillus anthracis cultures adsorbed on alum (aluminum potassium sulfate) or Alhydrogel (aluminum hydroxide) (8, 47). To develop and maintain protective immunity in humans, these vaccines must be administered subcutaneously six times over 18 months, and they require yearly booster injections (7, 40). The current vaccines are also associated with local side effects from the alum adjuvant and have shown only partial protection from infection with some strains of B. anthracis in animal models (10, 39). After the intentional release of anthrax spores in 2001, it was clear that a more effective, easily administered, and safer vaccine was needed for emergency situations (2, 14, 25, 41).
B. anthracis secretes a tripartite toxin comprised of a protective antigen (PA) (83 kDa), a lethal factor (LF) (90 kDa), and an edema factor (89 kDa) (1, 23, 32). PA, a cell receptor-binding protein, is considered a primary immunogen for the development of protective immunity against anthrax (20, 24, 25). Immunity to PA has been shown to protect animals against inhalational anthrax (21, 55). Recent research has focused on the design of a recombinant PA (rPA) vaccine which would eliminate the need for filtered culture supernatants or whole B. anthracis lysate, as well as produce a more consistent immunogen (44, 53).
While most work with rPA has focused on intramuscular vaccination with alum, a vaccine applied to mucosal surfaces without the need for injection would be preferable for the rapid immunization of large, at-risk populations after potential exposure to anthrax. Also, mucosal immunization leads to both mucosal and systemic immunity (9, 31), which may be of value in preventing inhalation anthrax. Mucosal vaccine development has been limited mainly due to the lack of effective mucosal adjuvants. While several new human adjuvants have been studied, including monophosphorylated lipid A (MPL A), saponin QS-21, and muramyl tripeptide linked with dipalmitol phosphatidylethanolamine, these have been investigated predominantly for injectable vaccines (5, 20, 34). Recent attempts at mucosal vaccines for rPA involve adjuvants using soy phosphatidyl choline, cholera toxin (CT), and CpG oligonucleotides (6, 13). However, the development of Bell's palsy, associated with a nasal influenza vaccine adjuvanted with a bacterial toxin, raises safety concerns about the use of inflammatory materials as mucosal adjuvants (35).
This study examines the use of soybean oil-and-water nanoemulsions (NEs) (NanoBio Corporation, Ann Arbor, MI) as a mucosal adjuvant for an rPA vaccine. We have previously demonstrated that these NEs have broad antimicrobial activity (3, 17) and are safe and effective noninflammatory mucosal adjuvants for a whole-virus-based influenza vaccine (36). NEs in the present studies are simply mixed with rPA and applied to the nares of mice and guinea pigs for characterization of anti-PA immune responses. We assessed the induction of both mucosal and systemic anti-PA antibodies by immunization with these formulations, evaluated the ability of the animals' sera to neutralize anthrax lethal toxin (LeTx), and tested for protective immunity with B. anthracis Ames strain spore challenges. Our results show that the NE is potentially an effective adjuvant for an rPA mucosal vaccine.
MATERIALS AND METHODS
Animals.
Pathogen-free, female BALB/c and CBA/J mice (5 to 6 weeks old) and Hartley guinea pigs (females, 250 g) were purchased from Charles River Laboratories (Wilmington, MA). The mice and guinea pigs were housed in accordance with the American Association for Accreditation of Laboratory Animal Care standards. All procedures involving animals were performed according to the University Committee on Use and Care of Animals at the University of Michigan, the Institutional Animal Care and Use Committee at the University of Texas Medical Branch at Galveston, and standard operating procedures at Battelle Memorial Institute, Columbus, OH.
Reagents.
B. anthracis rPA and rLF were obtained from List Biological Laboratories, Inc. (Campbell, CA) and BEI Resource Repository (ATCC) as lyophilized preparations of purified proteins. After reconstitution in sterile Milli-Q water (5 mg/ml), the aliquots were stored at −80°C. A 20-mer oligonucleotide (ODN) (5′-TCC ATG ACG TTC CGT ACG TT-3′) (33), containing nonmethylated CpG repeats, was synthesized by Integrated DNA Technologies (Coralville, IA). The Escherichia coli MPL A (catalog no. L-6638), phytohemagglutinin phosphate (PHA-P), bovine serum albumin (BSA), dithiothreitol, and other chemicals used in buffers were purchased from Sigma-Aldrich Corporation (St. Louis, MO). The phosphate-buffered saline (PBS) and cell culture media were purchased from GIBCO (Grand Island, NY), and fetal bovine serum (FBS) was purchased from HyClone (Logan, UT). The alkaline phosphatase (AP)-conjugated antibodies, goat anti-mouse immunoglobulin G (IgG) (catalog no. A-3562), and goat anti-mouse IgA (α-chain specific; catalog no. A-4937) were purchased from Sigma, and goat anti-mouse IgE horseradish peroxidase (HRP) conjugate was purchased from Bethyl, Montgomery, TX (catalog no. A90-115P). The cell proliferation kit (XTT) was purchased from Roche Diagnostics.
rPA-adjuvant formulations.
NE (formulation W205EC) was supplied by NanoBio Corporation, Ann Arbor, MI. This NE is manufactured by the emulsification of cetyl pyridum chloride (1%), Tween 20 (5%), and ethanol (8%) in water with hot-pressed soybean oil (64%), using a high-speed emulsifier. Other than the cetyl pyridum chloride, W205EC is formulated with surfactants and food substances considered “generally recognized as safe” by the FDA. W205EC can be manufactured under good manufacturing practices and is stable for at least 18 months at 40°C without any special storage conditions. NE diameter was determined by dynamic light scattering using the NICOMP 380 ZLS (PSS NICOMP Particle Sizing Systems, Santa Barbara, CA). The mean droplet size was consistently below 400 nm.
All rPA-NE formulations were prepared 30 to 60 min prior to immunization by mixing rPA protein solution with NE, using saline as a diluent. Mouse immunization studies were performed using a 20-μg dose of rPA mixed with NE concentrations of 0.1% 0.5%, 1%, and 2%. For immunization with immunostimulants, 20 μg rPA was mixed with either 5 μg of MPL A or 10 μg CpG oligonucleotides in saline. The rPA aluminum hydroxide formulation (rPA-Alu) (catalog no. A-8222; Sigma) was prepared following the adsorption procedure described by Little et al. (27). Guinea pig immunization studies were performed with 10-μg, 50-μg, and 100-μg doses of rPA mixed with 1% NE and saline as a diluent. The immunization volume was 10 μl/nare for mice and 50 μl/nare for guinea pigs.
Immunization procedures.
For each experiment, groups of mice (n = 5) were immunized intranasally with either one or two administrations of experimental vaccine 3 weeks apart. Animals were monitored for adverse reactions, and antibody responses were measured at 3- to 4-week intervals over a period of up to 12 weeks. The immunizations were conducted by first anesthetizing the mice with Isoflurane and then holding them in an inverted position. rPA-NE mixes were applied to the nares with a pipette tip (10 μl per nare), and the animals were then allowed to inhale the material.
Hartley guinea pigs were vaccinated intranasally with one or two administrations of vaccine (50 μl per nare) 4 weeks apart, and antibody responses were measured at 3- to 4-week intervals over a period of up to 22 weeks.
Collection of blood, bronchial alveolar lavage (BAL) fluid, and splenocytes.
Blood samples were obtained from the saphenous vein at various time points during the course of the trials. The terminal sample was obtained by cardiac puncture from euthanatized, premorbid mice. Serum was obtained from blood by centrifugation at 1,500 × g for 5 min after allowing it to coagulate for 30 to 60 min at room temperature. Serum samples were stored at −20°C until analyzed.
BAL fluid was obtained from mice euthanatized by Isoflurane inhalation. After the trachea was dissected, a 22-gauge catheter (Angiocath; B-D) attached to a syringe was inserted into the trachea. The lungs were infused twice with 0.5 ml of PBS containing 10 μM dithiothreitol and 0.5 mg/ml aprotinin (protease inhibitors), and approximately 1 ml of aspirate was recovered. BAL samples were stored at −20°C for further study.
Murine splenocytes were mechanically isolated to obtain single-cell suspension in PBS. Red blood cells were removed by lysis with ACK buffer (150 mM NH4Cl, 10 mM KHCO3, 0.1 mM Na2EDTA), and the remaining cells were washed twice in PBS. For the antigen-specific proliferation or cytokine expression assays, splenocytes (2 × 106 to 4 × 106/ml) were resuspended in RPMI 1640 medium supplemented with 2% FBS, 200 nM l-glutamine, and penicillin-streptomycin (100 U/ml and 100 μg/ml).
Determination of anti-PA IgG and IgA.
Mouse anti-PA-specific IgG and IgA levels were determined by enzyme-linked immunosorbent assay (ELISA). Microtiter plates (Nunc) were coated with 5 μg/ml (100 μl) of rPA in a coating buffer (50 mM sodium carbonate, 50 mM sodium bicarbonate, pH 9.6) and incubated overnight at 4°C. After the protein solution was removed, plates were blocked for 30 min with PBS containing 1% dry milk. The blocking solution was aspirated, and plates were used immediately or stored sealed at 4°C until needed. Serum and BAL samples were serially diluted in 0.1% BSA in PBS, and 100-μl/well aliquots were incubated in rPA-coated plates for 1 h at 37°C. Plates were washed three times with PBS-0.05% Tween 20, followed by 1 h of incubation with either anti-mouse IgG or anti-mouse IgA AP-conjugated antibodies (Rockland), and then were washed three times and incubated with the AP substrate Sigma Fast (Sigma). The colorimetric reaction was stopped with 1 N NaOH according to the manufacturer's protocol, and readouts were performed using a Spectra Max 340 ELISA reader (Molecular Devices, Sunnyvale, CA) at 405 nm and the reference wavelength of 690 nm. The end point titers were recorded, and in the case of BAL fluid, the final antibody concentrations were calculated as described by Rhie et al. (43) from the standard curves obtained for each assay plate, using goat F(ab′)2 anti-mouse IgG as a capturing agent and known concentrations of mouse IgG and IgA, and were detected with anti-IgG or anti-IgA-AP conjugates.
Guinea pig anti-PA IgG was determined by the same method, except that rabbit anti-guinea pig IgG AP conjugate was used for detection (Rockland). Antibody concentrations are presented as the mean ± standard error of the mean (SEM) of end point titers.
Dot blot detection of IgE.
Saline rPA solution (2 μl; 5 μg/ml) was adsorbed onto Nytran membranes (0.2-μm pore; Schleicher and Schuell, Keene, NH) and air dried for 30 min at room temperature. The membrane was blocked with PBS with 1% dry milk for 30 min and then washed three times with PBS and air dried. For IgE detection, pooled sera from all groups of animals were diluted 1:10, 1:20, 1:40, and 1:80 in PBS with 0.1% BSA. Duplicate samples (2 μl) of each dilution were placed over the antigen spots and incubated at room temperature for 30 min. Following three washes in PBS, the dot blot was incubated with a 1:1,000 dilution of anti-mouse IgE HRP-conjugated antibody. After five washes with PBS, the dot blot was incubated with HRP substrate until dots were visible.
LeTx cytotoxicity and neutralizing antibody assay.
Neutralizing antibody assay was performed using serial dilutions of sera incubated for 1 h with LeTx (consisting of 0.1 μg/ml rPA and 0.1 μg/ml rLF in PBS). The antibody-toxin mixtures were then added to RAW264.7 cells (20,000 to 30,000 cells/well) and incubated for 4 to 6 h at 37°C. Cell viability was assessed by the XTT (2,3-bis[2-methyloxy-4-nitro-5-sulfophenyl]-2H-tetrazolium-5-carboxyanilide) assay. The serum titers resulting in 50% protection against LeTx cytotoxicity (50% neutralizing concentration [NC50]) were calculated from the cell viability curves and presented as the mean value for the individual sera. Samples were assayed in triplicate at least two different times.
Live spore challenge.
Challenge experiments were performed at the biosafety level 4 and 3 facilities at Battelle Memorial Institute (Columbus, OH) and the University of Texas Medical Branch (Galveston, TX), respectively. The intradermal challenges were performed according to Battelle study no. 556-G607602. Briefly, B. anthracis (Ames strain) spores were enumerated and diluted for intradermal spore challenge. A concentrated stock solution of Ames Battelle lot B22 was diluted in sterile water to an anticipated concentration of 5 × 103 CFU/ml. On study day 0, guinea pigs were intradermally challenged with a target dose of ∼500 spores (0.1 ml). Postchallenge enumeration of spores revealed the actual number to be 1,380, which corresponds to 1,000 times the intradermal 50% lethal dose (intradermal 1,000× LD50). The guinea pigs were observed twice daily for 14 days following the challenge for signs of clinical disease or death. Deaths were recorded to the nearest observation period. All animals surviving the challenge were anesthetized for terminal blood collection and then euthanatized on day 14 postchallenge. Intranasal challenges were performed according to the JWP-004-0012 nasal challenge SOP protocol. Briefly, B. anthracis (Ames strain) spores were enumerated and diluted in PBS without calcium and magnesium for intranasal spore challenge. Anesthetized guinea pigs were challenged by intranasal administration of either 1.2 × 106 or 1.2 × 107 spores, which corresponds, respectively, to the intranasal 10× LD50 and 100× LD50. Postchallenge observation of guinea pigs was performed as described above for intradermal challenge.
Proliferation assay.
The proliferation of mouse splenocytes was measured by assay of 5-bromo-2-deoxyuridine incorporation, using cell proliferation ELISA (Roche Molecular Biochemicals, Mannheim, Germany). In brief, the cells were incubated in the presence of rPA (5 μg/ml) or PHA-P mitogen (2 μg/ml) for 48 h and then pulsed with 5-bromo-2-deoxyuridine for 24 h. Cell proliferation was measured according to the manufacturer's instructions using a Spectra Max 340 ELISA reader at 370 nm and a reference wavelength of 492 nm.
Analysis of cytokine expression in vitro.
Freshly isolated mouse splenocytes were seeded at 2 × 106 cells/0.5 ml (RPMI 1640, 2% FBS) and incubated with rPA (5 μg/ml) or PHA-P mitogen (2 μg/ml) for 72 h. Cell culture supernatants were harvested and analyzed for the presence of cytokines. Interleukin-2 (IL-2), IL-4, gamma interferon (IFN-γ), and tumor necrosis factor alpha (TNF-α) cytokine assays were performed using Quantikine ELISA kits (R&D Systems, Inc., Minneapolis, MN) according to the manufacturer's instructions.
Statistical analysis.
Data from individual experiments were expressed as mean ± SEM. Statistical significance was determined by analysis of variance using the Student t and Fisher exact tests. All tests were at 95% confidence (two tailed). A P value of <0.05 was considered to be statistically significant.
RESULTS
Physicochemical analysis of rPA-NE vaccine formulations used in this study indicated that NE stabilized rPA protein, which retained a nonaltered structure and was protected against progressive degradation due to deamidation observed in a buffer solution (15, 57). In addition, the stability, appearance, and size (359 ± 109 nm) of NE adjuvant were not altered by the addition of the rPA protein.
rPA-NE immunization induces serum anti-PA antibodies.
The effect of the NE adjuvant on antibody response was measured in CBA/J and BALB/c mice. CBA/J mice were immunized intranasally with 20 μg rPA mixed with either 0.1%, 0.5%, 1%, or 2% NE. A rapid induction of anti-PA antibodies in serum was obtained in all vaccinated animals, with some dependence on the concentration of the NE. All CBA/J mice developed high titers of serum anti-PA IgG (end point titers ranging from 104 to 105) at 5 weeks, after only two administrations of the vaccine (at 1 day and at 3 weeks). Further assays at 8 to 12 weeks indicated that while there were lower titers in animals immunized with the 0.1% and 0.5% NE, there was no statistical difference between titers in animals immunized with either 1% or 2% rPA-NE. In contrast, no seropositive mice were found among animals intranasally immunized with rPA in saline (Fig. 1A). The pattern of the IgG subtype antibodies indicated a prevalence of IgG2a and IgG2b over IgG1, thus suggesting Th1 polarization of the immune response (Fig. 1A, inset). To further characterize the immune response generated by intranasal NE, BALB/c mice were immunized with 20 μg rPA mixed with 1% NE (rPA-NE) and compared to mice immunized with 20 μg rPA mixed with either MPL A (rPA-MPL A), unmethylated CpG ODN (rPA-CpG), or aluminum hydroxide (rPA-Alu) (39, 40, 42, 43). After two administrations of each formulation, all mice immunized with rPA-NE were seropositive, with anti-PA IgG end point titers of at least 105, compared to titers ranging from 102 to 103 in the rPA-MPL A, rPA-CpG, and rPA-Alu immunization groups (Fig. 1B). Again, no anti-PA antibodies were detected in animals nasally immunized with rPA in saline.
Serum was also analyzed for the presence of anti-PA IgE antibodies, which revealed anti-PA IgE (detectable at least a 1:80 dilution in dot blots) in mice intramuscularly immunized with rPA-Alu but not in any other group (Fig. 1B, inset). This is consistent with prior reports of alum adjuvant-based vaccines inducing a Th2 response (22, 26).
Intranasal rPA-NE vaccination produces mucosal immunity.
We hypothesized that nasal immunization may induce mucosal immunity to help protect against respiratory infection (9, 58). Significant levels of anti-PA-specific secretory IgA antibodies were observed in BAL samples from BALB/c mice vaccinated with rPA-NE (Fig. 2A). A similar pattern, with higher antibody concentrations, was detected for anti-PA IgG in BAL samples (Fig. 2B). The animals with titers of secretory IgA in BAL fluid also had detectable levels of serum anti-PA IgA. These data show that significant mucosal responses can be induced with an intranasal vaccine consisting of rPA in NE, but not with other formulations or with intramuscular immunizations (data not shown). No inflammatory response was observed in histopathological examination of animals' nasal mucosa after administration of NE with or without antigen, indicating that the NE is not proinflammatory.
The rPA-NE vaccine produces neutralizing antibodies against anthrax toxin in mice.
To evaluate whether the mucosal NE-based vaccine could produce toxin-neutralizing antibodies, sera from immunized mice were tested for the ability to neutralize anthrax LeTx. Sera from mice immunized with rPA-NE were effective in neutralizing LeTx and prevented RAW264.7 cell death, with an NC50 of >103. In contrast, sera from mice immunized with either rPA-MPL A, rPA-CpG, or rPA-Alu had NC50s of <10. Naive control sera or sera from mice immunized with rPA in saline did not inhibit LeTx cytotoxicity at any concentration (Fig. 3).
rPA-NE immunization yields Th1 cellular responses.
PA antigen-specific cellular responses were measured in a proliferation assay (Fig. 4) and through the analysis of the cytokine secretion from splenocytes stimulated in vitro with rPA (Table 1). As shown in Fig. 4, rPA stimulated proliferation only in splenocytes obtained from mice immunized with rPA-NE. No antigen-specific proliferation was detected in splenocytes from animals immunized with either rPA alone or rPA with CpG ODNs.
PA-activated spleen cells from mice vaccinated with rPA-NE showed increased expression of IFN-γ, TNF-α, and IL-2 but failed to produce IL-4, compared to the control (nonstimulated) cells. This suggests that nasal immunization with rPA-NE yields antigen-specific Th1-type polarization of cellular responses (Table 1).
rPA-NE vaccines protect guinea pigs against intradermal live spore challenge.
Three groups of three guinea pigs were vaccinated intranasally with 10-, 50-, and 100-μg doses of rPA mixed with 1% NE. IgG responses were observed after a single vaccination and continued to increase after a second administration (at 4 weeks), producing end point antibody titers of >1 × 105. The animals were subsequently followed for 6 months to evaluate the duration of immunity. Nasal immunization in these animals produced durable immune responses with high antibody titers (>104) for at least 6 months (Fig. 5A). At 6 months, the animals were challenged intradermally with 1,000× LD50 Ames strain spores. Survival data indicate that mucosal vaccination of guinea pigs with any of the three concentrations of rPA in NE produced 100% protection against the intradermal challenge, while none of the control animals survived (Fig. 5B). An LeTx neutralization assay before the challenge documented mean serum NC50 titers of 3 × 102 in the group immunized with 10 μg rPA-NE and of ∼1 × 103 in the groups immunized with 50 μg and 100 μg rPA-NE (Fig. 5B insert).
rPA-NE vaccines protect against intranasal spore challenge.
The protective effect of intranasal immunization was also tested in an inhalation challenge trial. Three groups of guinea pigs (n = 10) were immunized with formulations containing 10, 50, and 100 μg rPA mixed with 1% NE. Immunization consistently produced 100% seroconversion and significant anti-PA IgG responses in all immunized animals. A boost at 4 weeks resulted in the rapid increase of anti-PA IgG in the serum, producing end point antibody titers of >1 × 105 in all groups. An LeTx neutralization assay before the challenge indicated mean NC50 titers of 1 × 103 to 2 × 103 in all vaccinated groups (Fig. 6A). At 7 weeks the animals were challenged intranasally with either 10× LD50 (1.2 × 106 spores) or 100× LD50 (1.2 × 107 spores) of B. anthracis Ames strain spores. While none of the control guinea pigs survived, intranasal immunization with each formulation of rPA-NE produced protective immunity. rPA-NE immunizations yielded survival rates of 70% after the 10× LD50 challenge and 40% after the 100× LD50 challenge (Fig. 6B and C, respectively). The results of the 10× LD50 challenge suggest that the mucosal rPA-NE vaccine produced protective immunity comparable to that after intramuscular vaccination using rPA with alum (37). Although there was no difference in the overall survival of the guinea pigs vaccinated with rPA-NE in a range of rPA concentrations, there was a significant, dose-dependent extension of the mean time until death (TTD) in the immunized animals (Table 2).
DISCUSSION
The development of safe and efficacious adjuvants is crucial to produce new mucosal vaccines to protect against inhalation anthrax. In general, antigens delivered via the mucosa are poorly immunogenic and are easily degraded by mucosal enzymes. This has led to concerns that this approach may induce a state of tolerance instead of protective immunity (18, 46, 58). In this study, we present a novel mucosal adjuvant for anthrax vaccination that is both potent and free of toxicity. These stable and convenient preparations of NEs mixed with the rPA of B. anthracis have induced significant mucosal and systemic immune responses. The NE adjuvant is effective over a broad range of antigen concentrations, and only a single application (in guinea pigs) or two vaccinations (in mice) are necessary to induce protective immune responses. Despite the nasal route of immunization, significant protection against either intradermal or intranasal spore challenge was achieved.
The guinea pig is a primary model for testing anthrax vaccine efficacy (19, 20, 42). In our intranasal rPA-NE studies, complete protection was obtained against intradermal challenge with 1,000× LD50 of B. anthracis spores 5 months after booster immunization. This suggests that a durable anti-PA IgG response with neutralizing antibody titers of greater than 102 provides protection from dermal anthrax exposure. In comparison, intramuscular immunization with the commercial anthrax vaccine resulted in overall survival rates of 53% to 63% in guinea pigs after intramuscular challenges with 10× to 1,000× LD50 of Ames strain spores, and IgG titers alone did not predict protection (19). A high concentration (NC50 of >103) of the LeTx-neutralizing antibodies present in the sera of mice and guinea pigs after rPA-NE immunization indicates that mixing with NE adjuvant did not denature essential protective epitopes in the antigen that are important for protection against infection with live B. anthracis (44). Inhalational challenge of guinea pigs intranasally vaccinated with rPA-NE yielded 70% and 40% survival for 10× and 100× LD50 of Ames strain spores, respectively, while the neutralizing antibody titers were comparable (or higher) to these in fully protected intradermally challenged guinea pigs. These results were similar to those for other anthrax vaccines (21, 27) and suggest that anti-PA IgA, IgG, and neutralizing antibodies are not fully predictive for protection against inhalation anthrax. In addition, the intranasal challenge results indicate a complex mechanism of protection against inhalation infection with anthrax (50). However, even when not providing complete survival, rPA-NE immunization significantly extended the TTD (approximately 3 to 5 days) after intranasal challenge. This may provide potential therapeutic advantages for when mucosal rPA-NE immunization is used for postexposure anthrax prophylaxis in combination with antibiotics or anti-PA monoclonal antibodies (38, 52).
Although it is difficult to directly compare titers of anti-PA IgG antibodies achieved with various adjuvants and routes of administration, the NE appeared to generate immune responses at least equivalent to those with other adjuvants. CT increased the effectiveness of the rPA-based vaccine (13, 45). However, unlike for the NEs, NIAID has raised safety concerns about CT, because when delivered intranasally it can transit the cribiform plate via the olfactory nerve and can cause inflammation in the olfactory region of the brain (12, 49). In comparable studies using the same guinea pig intranasal challenge model (and performed at the same facility with the same protocol), intramuscular immunization with rPA adsorbed on Alhydrogel and immunization with the commercial AVA vaccine provided 100 and 70% protection, respectively, when challenge was with 5× LD50 of anthrax Ames strain spores (37). We used higher challenge doses and obtained equivalent to better protection, suggesting similar immunogenicity. Also, our intranasal vaccinations with rPA-NE vaccine typically resulted in at least 104- to 105-fold-higher titers of anti-PA antibodies than immunization with nonadjuvanted rPA. Therefore, NE adjuvants that both demonstrate high effectiveness and are made from “generally recognized as safe” materials and vegetable oils could be considered for use as safe and effective candidates for adjuvants in mucosal vaccines (17, 36).
Development of a protective humoral anti-PA response in humans or in various experimental animal models requires multiple immunizations with either parenteral or mucosal anthrax vaccines (6, 13, 21, 29, 30). This cumbersome administration schedule and the short duration of protective immunity are serious disadvantages for anthrax immunization in response to bioterrorist attacks. A recent study reported that two intramuscular vaccinations of macaques with rPA bound to Alhydrogel produced higher serum IgG responses than the licensed AVA vaccine. However, the IgG levels in those animals significantly decreased by 6 to 10 weeks after immunization (54). The reasons for the limited duration of immunity with these vaccines are unclear, and a direct comparison is complicated by differences in experimental models, but it is possible that the inherent instability of rPA leads to the degradation of critical antigenic epitopes (15, 16, 57). We found that the rPA-NE vaccine was effective in inducing high titers of anti-PA IgG after only two intranasal administration and produced durable, long-term (6-month) neutralizing immunity. Incubation with NE seemed to decrease degradation of rPA, possibly stabilizing its antigenicity (data not shown). Thus, the increased stability of the antigen may play a role in the enhanced adjuvant activity observed with NE.
Most studies of anthrax vaccines focus on serum IgG concentration as the primary marker of protective immunity (2, 25, 29). However, the NE adjuvant also induced mucosal immunity to PA. Significant concentrations of anti-PA IgA and IgG antibodies in mucosal secretions (BAL fluid) were detected in mice immunized with rPA-NE, although the value of mucosal immunity in protection against inhalation anthrax is unclear. rPA administered with either CpG ODN or MPL A immunostimulatory adjuvant (4, 51) was not effective in inducing a mucosal immune response. However, inclusion of MPL A into the NE-based vaccines resulted in a more rapid induction of serum anti-PA IgG but no change in the overall titer of anti-PA antibodies (data not shown). MPL A has proved to be an effective inducer of Th1 polarization of the immune response (48). An examination of the PA-specific cytokine secretion pattern in splenocytes after rPA-NE immunization and the prevalence of IgG2a and IgG2b subtype antibody suggest that the NE-based vaccine may result in a similar Th1 polarization (6, 11, 28). In contrast, the animals immunized with rPA-Alu had elevated levels of IgE and poor IgG and IgA responses, suggesting that their cellular immunity is biased toward a Th2 type of response (56). Thus, rPA-NE yields a serum and systemic adjuvant activity similar to that with MPL A, which may be why the combination of these adjuvants did not appear to be synergistic when administered intranasally.
In summary, our study indicates that NEs appear to be an effective mucosal adjuvant for a rPA anthrax vaccine. These formulations induce long-lasting, robust, and specific humoral and cellular responses; appear to lack adverse effects; and have the ability to stabilize the antigen.
FIG. 1.
FIG. 2.
FIG. 3.
FIG. 4.
FIG. 5.
FIG. 6.
TABLE 1.
| Cytokine | Mean concn (pg/ml) ± SEMb in splenic lymphocytes from: | ||||||
|---|---|---|---|---|---|---|---|
| rPA-NE-immunized mice | Control mice | ||||||
| −PA | +PA | −PA | +PA | ||||
| IFN-γ | 26.37 ± 8.10 | 93.30 ± 24.40* | 13.23 ± 2.33 | 15.40 ± 3.70 | |||
| TNF-α | 4.74 ± 2.62 | 22.62 ± 12.85* | 3.51 ± 2.34 | 2.50 ± 2.50 | |||
| IL-2 | 27.10 ± 2.62 | 59.00 ± 16.9* | 33.00 ± 17.30 | 35.00 ± 16.90 | |||
| IL-4 | 17.44 ± 2.17 | 21.76 ± 9.76 | 19.00 ± 2.73 | 18.17 ± 2.69 | |||
a
rPA-stimulated cytokine responses in harvested splenocytes in vitro are shown. Th1-type cytokine (IFN-γ, TNF-α, and IL-2) and Th2-type cytokine (IL-4) production was evaluated by specific ELISA of culture supernatant fluid from nonstimulated (−PA) and rPA-stimulated (+PA) cells.
b
*, statistically significant difference in cytokine concentrations between resting and rPA-stimulated cells (P < 0.05).
TABLE 2.
| Vaccination | 10× LD50 challenge | 100× LD50 challenge | ||||
|---|---|---|---|---|---|---|
| Mortality | TTDa (mean ± SD) | Mortality | TTD (mean ± SD) | |||
| PBS control | 10/10 | 3.8 ± 1.4 | 10/10 | 3.1 ± 1.1 | ||
| NE control | NDb | ND | 10/10 | 3.5 ± 1.1 | ||
| 10 μg rPA-NE | 3/10 | 7.0 ± 1.4* | 6/10 | 4.3 ± 1.2 | ||
| 50 μg rPA-NE | 3/10 | 8.3 ± 1.2* | 6/10 | 6.0 ± 1.4* | ||
| 100 μg rPA-NE | 3/10 | 9.7 ± 3.1* | 6/10 | 8.3 ± 1.2* | ||
a
*, significant differences (P < 0.05) between TTDs of vaccinated animals and controls.
b
ND, not determined.
Acknowledgments
This project has been funded in part by the National Institute of Allergy and Infectious Diseases, NIH, via the Great Lakes Regional Center of Excellence, University of Chicago, under award U54 AI57153 and by funds from the Michigan Nanotechnology Institute for Medicine and Biological Sciences.
We thank Kathyrn Bush and Jennifer Pawlik of University of Texas Medical Branch at Galveston for their technical assistance with the animal experiments.
REFERENCES
1.
Ascenzi, P., P. Visca, G. Ippolito, A. Spallarossa, M. Bolognesi, and C. Montecucco. 2002. Anthrax toxin: a tripartite lethal combination. FEBS Lett.531:384-388.
2.
Baillie, L. 2001. The development of new vaccines against anthrax. J. Appl. Microbiol.9:609-613.
3.
Baker, J. R. J., D. C. Wright, M. M. Hayes, T. Hamouda, and J. Brisker. January 2000. Methods for inactivating bacteria including bacterial spores. U.S. patent 6,015,832.
4.
Baldrick, P., D. Richardson, G. Elliott, and A. W. Wheeler. 2002. Safety evaluation of monophosphoryl lipid a (MPL): an immunostimulatory adjuvant. Regul. Toxicol. Pharmacol.35:398-413.
5.
Baldridge, J. R., and R. T. Crane. 1999. Monophosphoryl lipid A (MPL) formulations for the next generation of vaccines. Methods19:103-107.
6.
Boyaka, P. N., A. Tafaro, R. Fischer, S. H. Leppla, K. Fujihashi, and J. R. McGhee. 2003. Effective mucosal immunity to anthrax: neutralizing antibodies and Th cell responses following nasal immunization with protective antigen. J. Immunol.170:5636-5643.
7.
Brachman, P. S., H. Gold, S. Plotkin, F. R. Frkety, M. Werrimn, and N. R. Ingraham. 1962. Field evaluation of human anthrax vaccine. Am. J. Public Health52:632-645.
8.
Brey, R. N. 2005. Molecular basis for improved anthrax vaccines. Adv. Drug Deliv. Rev.57:1266-1292.
9.
Davis, S. S. 2001. Nasal vaccines. Adv. Drug Deliv. Rev.51:21-42.
10.
Fellows, P. F., M. K. Linscott, B. E. Ivins, M. L. M. Pitt, C. A. Rossi, P. H. Gibbs, and A. M. Friedlander. 2001. Efficacy of a human anthrax vaccine in guinea pigs, rabbits, and rhesus macaques against challenge by Bacillus anthracis isolates of diverse geographical origin. Vaccine19:3241-3247.
11.
Finkelman, F. D., J. Holmes, I. M. Katona, J. F. Urban, M. P. Beckmann, L. S. Park, K. A. Schooley, R. L. Coffman, T. R. Mosmann, and W. E. Paul. 1990. Lymphokine control of in vivo immunoglobulin isotype selection. Annu. Rev. Immunol.8:303-333.
12.
Fujihashi, K., T. Koga, F. W. van Ginkel, Y. Hagiwara, and J. R. McGhee. 2002. A dilemma for mucosal vaccination: efficacy versus toxicity using enterotoxin-based adjuvants. Vaccine20:2431-2438.
13.
Gaur, R., P. K. Gupta, A. C. Banerjea, and Y. Singh. 2002. Effect of nasal immunization with protective antigen of Bacillus anthracis on protective immune response against anthrax toxin. Vaccine20:2836-2839.
14.
Goodman, L. 2004. Taking the sting out of the anthrax vaccine. J. Clin. Investig.114:868-869.
15.
Gupta, P. K., H. Chandra, R. Gaur, R. K. Kurupati, S. Chowdhury, V. Tandon, Y. Singh, and K. Maithal. 2003. Conformational fluctuations in anthrax protective antigen: a possible role of calcium in the folding pathway of the protein. FEBS Lett.554:505-510.
16.
Gupta, P. K., R. K. Kurupati, H. Chandra, R. Gaur, V. Tandon, Y. Singh, and K. Maithal. 2003. Acid induced unfolding of anthrax protective antigen. Biochem. Biophys. Res. Commun.311:229-232.
17.
Hamouda, T., A. Myc, B. Donovan, A. Y. Shih, J. D. Reuter, and J. R. Baker, Jr. 2001. A novel surfactant nanoemulsion with a unique non-irritant topical antimicrobial activity against bacteria, enveloped viruses and fungi. Microbiol. Res.156:1-7.
18.
Holmgren, J., and C. Czerkinsky. 2005. Mucosal immunity and vaccines. Nat. Med.11:45-53.
19.
Ivins, B. E., P. F. Fellows, and G. O. Nelson. 1994. Efficacy of a standard human anthrax vaccine against Bacillus anthracis spore challenge in guinea-pigs. Vaccine12:872-874.
20.
Ivins, B. E., P. F. Fellows, L. Pitt, J. Estep, J. Farchaus, A. M. Friedlander, and P. H. Gibbs. 1995. Experimental anthrax vaccines: efficacy of adjuvants combined with protective antigen against an aerosol Bacillus anthracis spore challenge in guinea pigs. Vaccine13:1779-1784.
21.
Ivins, B. E., M. L. M. Pitt, P. F. Fellows, J. W. Farchaus, G. E. Benner, D. M. Waag, S. F. Little, J. G. W. Anderson, P. H. Gibbs, and A. M. Friedlander. 1998. Comparative efficacy of experimental anthrax vaccine candidates against inhalation anthrax in rhesus macaques. Vaccine16:1141-1148.
22.
Johansson, J., A. Ledin, M. Vernersson, K. Lovgren-Bengtsson, and L. Hellman. 2004. Identification of adjuvants that enhance the therapeutic antibody response to host IgE. Vaccine22:2873-2880.
23.
Leppla, S. H. (ed.). 1995. Bacterial toxins and virulence factors in diseases. Handbook of natural toxins, vol. 8. Marcel Dekker, New York, NY.
24.
Leppla, S. H. 2001. A dominant-negative therapy for anthrax. Nat. Med.7:659-660.
25.
Leppla, S. H., J. B. Robbins, R. Schneerson, and J. Shiloach. 2002. Development of an improved vaccine for anthrax. J. Clin. Investig.110:141-144.
26.
Lindblad, E. B. 2004. Aluminium adjuvants—in retrospect and prospect. Vaccine22:3658-3668.
27.
Little, S. F., W. M. Webster, B. E. Ivins, P. F. Fellows, S. L. Norris, and G. P. Andrews. 2004. Development of an in vitro-based potency assay for anthrax vaccine. Vaccine22:2843-2852.
28.
Marinaro, M., P. N. Boyaka, R. J. Jackson, F. D. Finkelman, H. Kiyono, E. Jirillo, and J. R. McGhee. 1999. Use of intranasal IL-12 to target predominantly Th1 responses to nasal and Th2 responses to oral vaccines given with cholera toxin. J. Immunol.162:114-121.
29.
McBride, B. W., A. Mogg, J. L. Telfer, M. S. Lever, J. Miller, P. C. B. Turnbull, and L. Baillie. 1998. Protective efficacy of a recombinant protective antigen against Bacillus anthracis challenge and assessment of immunological markers. Vaccine16:810-817.
30.
Mikszta, J. A., J. P. Dekker III, N. G. Harvey, C. H. Dean, J. M. Brittingham, J. Huang, V. J. Sullivan, B. Dyas, C. J. Roy, and R. G. Ulrich. 2006. Microneedle-based intradermal delivery of the anthrax recombinant protective antigen vaccine. Infect. Immun.74:6806-6810.
31.
Mikszta, J. A., V. J. Sullivan, C. Dean, A. M. Waterston, J. B. Alarcon, J. P. r. Dekker, J. M. Brittingham, J. Huang, C. R. Hwang, M. Ferriter, G. Jiang, K. Mar, K. U. Saikh, B. G. Stiles, C. J. Roy, R. G. Ulrich, and N. G. Harvey. 2005. Protective immunization against inhalational anthrax: a comparison of minimally invasive delivery platforms. J Infect. Dis.191:278-288.
32.
Milne, J. C., S. R. Blanke, P. C. Hanna, and R. J. Collier. 1995. Protective antigen-binding domain of anthrax lethal factor mediates translocation of a heterologous protein fused to its amino- or carboxy-terminus. Mol. Microbiol.15:661-666.
33.
Moldoveanu, Z., A. N. Vzorov, W. Q. Huang, J. Mestecky, and R. W. Compans. 1999. Induction of immune responses to SIV antigens by mucosally administered vaccines. AIDS Res. Hum. Retroviruses15:1469-1476.
34.
Moschos, S. A., V. W. Bramwell, S. Somavarapu, and H. O. Alpar. 2005. Comparative immunomodulatory properties of a chitosan-MDP adjuvant combination following intranasal or intramuscular immunisation. Vaccine23:1923-1930.
35.
Mutsch, M., W. Zhou, P. Rhodes, M. Bopp, R. T. Chen, T. Linder, C. Spyr, and R. Steffen. 2004. Use of the inactivated intranasal influenza vaccine and the risk of Bell's palsy in Switzerland. N. Engl. J. Med.350:896-903.
36.
Myc, A., J. F. Kukowska-Latallo, A. U. Bielinska, P. Cao, P. P. Myc, K. Janczak, T. R. Sturm, M. S. Grabinski, J. J. Landers, and K. S. Young. 2003. Development of immune response that protects mice from viral pneumonitis after a single intranasal immunization with influenza A virus and nanoemulsion. Vaccine21:3801-3814.
37.
Patton, K., D. Higgins, A. Wenglikowski, K. Raja, R. McDonald, J. Peterson, and G. Van Nest. 2006. rPA delivered with a novel ISS oligonucleotide formulation protects guinea pigs and rabbits against anthrax challenge. Abstr. Am Soc. Microbiol. Bodefense Meet., abstr. 232.
38.
Peterson, J. W., J. E. Comer, D. M. Noffsinger, A. Wenglikowski, K. G. Walberg, B. M. Chatuev, A. K. Chopra, L. R. Stanberry, A. S. Kang, W. W. Scholz, and J. Sircar. 2006. Human monoclonal anti-protective antigen antibody completely protects rabbits and is synergistic with ciprofloxacin in protecting mice and guinea pigs against inhalation anthrax. Infect. Immun.74:1016-1024.
39.
Pittman, P. R., P. H. Gibbs, T. L. Cannon, and A. M. Friedlander. 2001. Anthrax vaccine: short-term safety experience in humans. Vaccine20:972-978.
40.
Pittman, P. R., D. Hack, J. Mangiafico, P. Gibbs, J. K. T. McKee, A. M. Friedlander, and M. H. Sjogren. 2002. Antibody response to a delayed booster dose of anthrax vaccine and botulinum toxoid. Vaccine20:2107-2115.
41.
Project Bioshield Act of 2004. 2004. Public law 108-276, 108th Congress (21 July 2004).
42.
Reuveny, S., M. D. White, Y. Y. Adar, Y. Kafri, Z. Altboum, Y. Gozes, D. Kobiler, A. Shafferman, and B. Velan. 2001. Search for correlates of protective immunity conferred by anthrax vaccine. Infect. Immun.69:2888-2893.
43.
Rhie, G., M. H. Roehrl, M. Mourez, R. J. Collier, J. J. Mekalanos, and J. Y. Wang. 2003. A dually active anthrax vaccine that confers protection against both bacilli and toxins. Proc. Natl. Acad. Sci. USA100:10925-10930.
44.
Ribot, W. J., B. S. Powell, B. E. Ivins, S. F. Little, W. M. Johnson, T. A. Hoover, S. L. Norris, J. J. Adamovicz, A. M. Friedlander, and G. P. Andrews. 2006. Comparative vaccine efficacy of different isoforms of recombinant protective antigen against Bacillus anthracis spore challenge in rabbits. Vaccine24:3469-3476.
45.
Singh, Y., B. E. Ivins, and S. H. Leppla. 1998. Study of immunization against anthrax with the purified recombinant protective antigen of Bacillus anthracis. Infect. Immun.66:3447-3448.
46.
Tsitoura, D. C., R. H. DeKruyff, J. R. Lamb, and D. T. Umetsu. 1999. Intranasal exposure to protein antigen induces immunological tolerance mediated by functionally disabled CD4+ T cells. J. Immunol.165:2592-2600.
47.
Turnbull, P. C. B. 1991. Anthrax vaccines: past, present and future. Vaccine9:533-539.
48.
Vajdy, M., I. Srivastava, J. Polo, J. Donnelly, D. O'Hagan, and M. Singh. 2004. Mucosal adjuvants and delivery systems for protein-, DNA- and RNA-based vaccines. Immunol. Cell Biol.82:617-627.
49.
van Ginkel, F. W., R. J. Jackson, Y. Yuki, and J. R. McGhee. 2000. Cutting edge: the mucosal adjuvant cholera toxin redirects vaccine proteins into olfactory tissues. J. Immunol.165:4778-4782.
50.
Vasconcelos, D., R. Barnewall, M. Babin, R. Hunt, J. Estep, C. Nielsen, R. Carnes, and J. Carney. 2003. Pathology of inhalation anthrax in cynomolgus monkeys (Macaca fascicularis). Lab. Investig.83:1201-1209.
51.
Vernacchio, L., H. Bernstein, S. Pelton, C. Allen, K. MacDonald, J. Dunn, D. D. Duncan, G. Tsao, V. LaPosta, and J. Eldridge. 2002. Effect of monophosphoryl lipid A (MPL(R)) on T-helper cells when administered as an adjuvant with pneumocococcal-CRM197 conjugate vaccine in healthy toddlers. Vaccine20:3658-3667.
52.
Vietri, N. J., B. K. Purcell, J. V. Lawler, E. K. Leffel, P. Rico, C. S. Gamble, N. A. Twenhafel, B. E. Ivins, H. S. Heine, R. Sheeler, M. E. Wright, and A. M. Friedlander. 2006. Short-course postexposure antibiotic prophylaxis combined with vaccination protects against experimental inhalational anthrax. Proc. Natl. Acad. Sci. USA103:7813-7816.
53.
Whiting, G. C., S. Rijpkema, T. Adams, and M. J. Corbel. 2004. Characterisation of adsorbed anthrax vaccine by two-dimensional gel electrophoresis. Vaccine22:4245-4251.
54.
Williamson, E. D., I. Hodgson, N. J. Walker, A. W. Topping, M. G. Duchars, J. M. Mott, J. Estep, C. LeButt, H. C. Flick-Smith, H. E. Jones, H. Li, and C. P. Quinn. 2005. Immunogenicity of recombinant protective antigen and efficacy against aerosol challenge with anthrax. Infect. Immun.73:5978-5987.
55.
Wimer-Mackin, S., M. Hinchcliffe, C. R. Petrie, S. J. Warwood, W. T. Tino, M. S. Williams, J. P. Stenz, A. Cheff, and C. Richardson. 2006. An intranasal vaccine targeting both the Bacillus anthracis toxin and bacterium provides protection against aerosol spore challenge in rabbits. Vaccine24:3953-3963.
56.
Yamanishi, R., I. Yusa, N. Bando, and J. Terao. 2003. Adjuvant activity of alum in inducing antigen specific IgE antibodies in BALB/c mice: a reevaluation. Biosci. Biotechnol. Biochem.67:166-169.
57.
Zomber, G., S. Reuveny, N. Garti, A. Shafferman, and E. Elhanany. 2005. Effects of spontaneous deamidation on the cytotoxic activity of the Bacillus anthracis protective antigen. J. Biol. Chem.280:39897-39906.
58.
Zuercher, A. W. 2003. Upper respiratory tract immunity. Viral Immunol.16:279-289.
Information & Contributors
Information
Published In
Copyright
© 2007 American Society for Microbiology.
History
Received: 12 January 2007
Revision received: 30 March 2007
Accepted: 1 May 2007
Published online: 1 August 2007
Contributors
Metrics & Citations
Metrics
Note:
- For recently published articles, the TOTAL download count will appear as zero until a new month starts.
- There is a 3- to 4-day delay in article usage, so article usage will not appear immediately after publication.
- Citation counts come from the Crossref Cited by service.
Citations
Citation
2007.
Mucosal Immunization with a Novel Nanoemulsion-Based Recombinant Anthrax Protective Antigen Vaccine Protects against Bacillus anthracis Spore Challenge. Infect Immun
75:.
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. For an editable text file, please select Medlars format which will download as a .txt file. Simply select your manager software from the list below and click Download.